2004 Ford F-350 Engine Problems
- 14
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 14 stored complaint records:
- 0 indicate a crash
- 0 indicate injury
- 1 indicate fire
What owners report
- failure mileage · 5 records
- repaired notified · 4 records
- notified failure · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 150–400k mi | 8 |
| 30–60k mi | 2 |
| 60–100k mi | 2 |
| 100–150k mi | 2 |
Complaint records
Owner-submitted complaint content, presented as stored.
Engine · Vehicle Speed Control
Tl* the contact owns a 2004 ford f-350. While driving various speeds, the vehicle suddenly shut off. Also, while idling, the engine rpms remained very high and the vehicle would attempt to surge forward. The vehicle was taken to an independent mechanic who replaced the icp sensor and injector control sensor, but the failures continued. The manufacturer and local dealer were not notified of the failures. The failure…
ODI 11203466
Engine
Tl* the contact owns a 2004 ford f-350. While driving approximately 20 mph, the vehicle stalled without warning. The contact coasted the vehicle to the shoulder to a complete stop. The vehicle was started normally, but stalled again the same afternoon. The vehicle was not diagnosed or repaired. The vin was excluded from nhtsa campaign number: 05v270000 (engine). The vehicle was not repaired. The manufacturer was…
ODI 10971851
Engine
Tl*the contact owns a 2004 ford f-350. The contact stated that while driving at approximately 55 mph, the vehicle stalled. The vehicle was taken to an independent mechanic, who discovered that oil was leaking from the head gasket. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 210,000.
ODI 10682591
Engine
Tl* the contact owns a 2004 ford f-350. The contact stated that while driving at approximately 15 mph, the vehicle stalled without warning. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 37,237.
ODI 10654705
Engine
Vehicle will not start, cranks but does not start. Diagnosed and replaced cam position sensor. *tr
ODI 10640863
Engine
Tl* the contact owns a 2004 ford f-350. The contact stated while driving various speeds the vehicle would suddenly hesitate and the speed would decelerate. The vehicle was taken to the dealer who diagnosed that the injector control pressure sensor was faulty. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 100,000.
ODI 10598607
Engine
While driving vehicle has intermittent loss of power, diagnosed and serviced egr valve, replaced egr throttle valve and sealed the boost inlet tube. *tr
ODI 10640860
Engine
Check engine light/no power/hard starting- replaced exhaust back pressure sensor- vehicle failure of ambulance responding to a call. *tr
ODI 10640854
Engine
Vehicle hard starting caused by failure of high pressure oil pump, replaced icp regulator, replaced egr valve and intake gaskets. *tr
ODI 10640835
Electrical System · Engine
For unknown reasons on 12/20/13 at 0030 hrs my truck caught on fire as it sat in my driveway. I drove the truck last on 12/14/13. The fire started in the engine compartment on the drivers side. I have owned the truck for about 8 months and it had 105000 miles on it when i purchased it. The fire department advised it could be due to some type of electrical issue near the master cylinder. I told them that i have not…
Fire reported
ODI 10556774
Engine
Tl* the contact owns a 2004 ford f-350. The contact stated that the vehicle stalled without warning while driving 65 mph. The vehicle was towed to the contact's residence where an independent mechanic performed a diagnostic. The failure was located at the fuel injection pressure sensor. The manufacturer was contacted and advised that the vin was not included in nhtsa campaign number 05v270000 (electrical system).…
ODI 10524196
Engine
Cracked head, resulting in coolant in engine oil, hard starting or failure to start. *tr
ODI 10640833
Engine
Cam position sensor failure, vehicle will not start, found coolant in oil on repair. *tr
ODI 10640830
Engine
My vehicle has been bucking and jerking intermittently since way before above.date it stopped running at a stop sign then bucked and jerked so in 2013 it got so bad that i finally had it checked out. I thought it was transmission, had it checked and was referred to local mechanic who was acquainted with the problem and has worked on several trucks with the 6.0 diesel engine. He said for $1200 you might repair it, no…
ODI 10654220