2012 Ford F-350 Exhaust System Problems
- 5
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- exhaust temperature · 4 records
- temperature sensor · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 1–30k mi | 2 |
| 30–60k mi | 2 |
| 60–100k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Exhaust System
Tl* the contact owns a 2012 ford f-350. After the contact started the vehicle, the engine stalled without warning. The vehicle was taken to the dealer who stated that the egt exhaust temperature sensor needed to be replaced. The vehicle was repaired and the manufacturer was notified of the failure. The vin was unavailable. The approximate failure mileage was 68,178.
ODI 10649756
Diesel · Exhaust System
Was going into an intersection and my f-350 died and displays a stop safely now message, which caused me to die right before i went through the intersection. Ended up being an egt sensor. Their are 4 on this truck and now another one has gone out leaving me stranded again. This ha sbecome such an issue that ford has a national backorder on these sensors, and they wont warranty the part, and the extended warranty…
ODI 10640978
Diesel · Exhaust System
The exhaust gas temperature sensor (egt) #13 on my 2012 ford diesel f350 failed and immediately shutdown the truck in the middle of the tollroad at 65 mph. The problem subsequently endangered my vehicle, life, and response personnel. The truck would then not restart until an hour later. This same problem has been reported by many other ford diesel truck owners on the internet. Why in the heck would ford design an…
ODI 10574838
Diesel · Exhaust System
Tl* the contact owns a 2012 ford f-350 sd. The contact stated that while driving 75 mph, the stop vehicle now warning message illuminated. The vehicle also lost power. The vehicle was towed to a dealer, who performed a diagnostic test and advised the contact that the egt exhaust temperature sensor was defective. The dealer replaced the exhaust temperature sensor replaced. The failure mileage was 4,882.
ODI 10513931
Diesel · Exhaust System
While towing loaded trailer on 2 lane highway, truck computer flashed message to "stop safely now". Engine shut down and would not restart. Dealer inspection found a faulty egt exhaust sensor. No other issues with cooling, oil or engine occurred. The safety issue is that the new control system software is designed to shut down engine in the event of a faulty sensor in order to protect the vehicle. The system should…
ODI 10503797