2015 Ford F-350 Fuel/Propulsion System Problems
- 9
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- engine idle · 6 records
- exhaust fluid · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 1–30k mi | 4 |
| 30–60k mi | 2 |
| 60–100k mi | 2 |
| 100–150k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel/Propulsion System
Same problem w/ the def heating unit as on earlier/similar f-series trucks that have compelled ford to issue extended warranty (see customer satisfaction program 18m01) -- a dtc208a error comes up, indicating failure in the def sender/heater. Not clear why ford is omitting the 2015 f350 powerstrokes when they're using the same part and built in the same factory as the models that have had the warranty extended.
ODI 11270968
Engine · Fuel/Propulsion System · Power Train
On my 2115 ford f 350 powerstroke diesel the check engine light came on and it de rated the power. I read the cel code and its pb20a which is a redactant heater performance failure. This problem is covered under warranty for all models 2011-14, f250-f 550 and 2015 f450, f550 only. Ford isn't covering the f250 of f350 in the 2015 years. My truck meets the date and manufacturing plant criteria and it is no drivable…
ODI 11265376
Engine · Fuel/Propulsion System
I was driving out of state (ny) when an alert stated "low fuel pressure) and the vehicle slowed to 5-10 mph while traveling on the interstate. Upon exiting, the vehicle stopped running leaving me and my family stranded. I had it towed to a local shop which informed me the bosch high pressure fuel pump was not delivering the required pressure (/,000 psi). Upon contacting the ford dealership where the vehicle was…
ODI 11254280
Engine · Fuel/Propulsion System · Power Train
Diesel exhaust fluid reductant heater fault, check engine light has illuminated and is not covered under previous recalls. Recurring problem for ford super duty that needs to be extended for this model as it is the same problem that previous attention was given to. It is a emissions problem that fails on these trucks.
ODI 11187014
Engine · Fuel/Propulsion System
Exhaust filter cleaning when that warning comes on my trucks engine is really rough and shakes. This is when driving to clear the exhaust filter.
ODI 11111026
Fuel/Propulsion System
Def tank filled at 7300 miles. At 9600 miles a "exhaust fluid low" 50 miles til engine idle. Picked up exhaust fluid and refilled-only 2 gals added to overflowing. Did not reset, went to stanley ford kenai, ak. Countdown went on, then"engine idle at next restart" dealer says to bad nox sensors, replaced and codes cleared. 15 miles later, exhaust system failure" engine will idle soon" fortunately i made it home in…
ODI 10893529
Engine · Fuel/Propulsion System · Power Train
During regeneration of the diesel particulate filter the truck loses power and operates roughly. This last occurred as i was merging into traffic on the highway during slick road conditions. This could have very easily resulted in loss of traction and/or collision as i was unable to accelerate to speed.
ODI 10819844
Fuel/Propulsion System
Would not regenerate when required. Went into filter full service now mode. Then check engine light came on.
ODI 10767568
Fuel/Propulsion System
Exhaust fluid message on dash that speed will be limited to in 50 miles. Went and bought a new jug of blue def. It took 2 gallons to fill to running over. Then before i got to the kenai, ak dealer, it says engine will idle upon restart. The kenai, ak dealer said up and down stream nox sensors had failed and reset the codes. 15 miles later, i get and "exhaust system failure" engine will idle soon. Made it home(40…
ODI 10893458