Ford F-350 Fuel System, Diesel Problems
- 52
- Owner complaint records in our dataset
- 12
- Years with records
- 1999–2015
- Stored years
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 52 stored complaint records:
- 0 indicate a crash
- 0 indicate injury
- 2 indicate fire
Complaints by year
What appears in the records
- fuel tank · 31 records
- fuel pump · 11 records
- fuel system · 9 records
- without warning · 8 records
- needed replaced · 6 records
- failure mileage · 6 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 12 |
| 30–60k mi | 12 |
| 1–30k mi | 11 |
| 100–150k mi | 7 |
| 150–400k mi | 4 |
Complaint evidence
Latest stored owner-submitted records. Open a year for the full list.
Engine · Fuel System, Diesel
2015 f350 6.7 diesel with 46,000 miles that is down because hpop is defective and spreading medal through system. Ford has inspected and said it is because of water in fuel, even though no warning lights or codes are available. Ford pulled sensors out of engine and rejected repair because of tarnish on sensors. The only codes were for (low fuel pressure & reduced power). No other codes. Initial inspection revealed…
ODI 10892303
Fuel System, Diesel · Fuel/Propulsion System
01/2016: vehicle was being driven home from work when there was a loss of engine power. Vehicle was able to roll to a stop in the parking lot of a church. Later it was determined this resulted from failure of #7 cylinder injector unit, believed to have failed due to delamination inside of fuel tank. About 02/23/2014, 207980 miles: fuel tank had been removed and internal screens cleared due to the engine stalling…
ODI 10936826
Engine · Fuel System, Diesel · Power Train
I have a 2005 ford f350 diesel powerstroke that has the fuel tank lining falling off and its gotten to my fuel lines and fuel pump causing the truck to come to a complete stop while i was driving down the freeway hauling a 12ft trailer with a 10000 lbs tractor on it. I had to get it towed to a shop where they replaced the fuel pump and filters. One month later it did the same thing while on the highway again it just…
ODI 10676166
Electrical System · Engine · Fuel System, Diesel
I was driving in my neighborhood at about 25 mph and the engine quit, and would not restart!! Also the ignition switch would allow the starter to stay engaged!! Had to turn the key off for the starter to stop!! The truck had to be towed to the dealer and it has beet there for over a week and they called yesterday and told me there were metal shavings in the fuel pump and i do not know if the metal shavings got into…
ODI 10622326
Diesel · Fuel System, Diesel
Cpsc: 2005 f-350. Consumer stated the 6.0 diesel motor is no longer working due to a buildup in the gas tank, or oil system. *ss the consumer stated after the vehicle was fixed, it broke down again. *jb
ODI 10838357
Fuel System, Diesel
This diesel truck was being driven at 20 mph when without any warning, the engine shut off resulting in loss of all power steering and brakes. Would not restart. Towed to dealer service. Dealer diagnosed lack of fuel pressure and they observed metal shavings in the lower filter indicating the hpfp was disintegrating. Dealer submitted pictures of the flow control valve to ford warranty prior approval per service…
ODI 10593571
Engine · Fuel System, Diesel
The engine light came on today in my 2011 f350 diesel . Dealer says def pump error code. Dealer says no pumps available until 03/15/2014. I think ford should issue a service bulletin. Dealer says no warranty. Dealer states truck will shut down at any time. This should become a recall issue with the nhtsa. Owners of these trucks tow trailers frequently with lengths in excess of 36'. Having a tow vehicle shut down in…
ODI 10563967
Fuel Pump · Fuel System, Diesel
Tl* the contact owns a 2005 ford f-350. The contact stated that while driving at 30 mph, the engine stalled without warning. The failure occurred on numerous occasions. The vehicle was taken to a dealer on several occasions where it was diagnosed that the motor needed to be replaced. The vehicle was repaired but the failure recurred. On another occasion the vehicle was taken to the dealer, where it was diagnosed…
ODI 10643953